Synergistic effect of waste glass powder and fly ash on some properties of mortar and notably suppressing alkali-silica reaction
DOI:
https://doi.org/10.7764/RDLC.22.2.419Keywords:
Alkali silica reaction, glass powder, fly ash, expansion.Abstract
In this study the mitigation influence of incorporating waste glass powder (G) and class F fly ash (F) in mortar as partial cement replacement on the alkali-silica reaction (ASR) between reactive aggregate and alkali contents of cement were investigated. Waste G and F replaced cement separately and together on mass basis at 10%, 20%, and 30%. The unit weight (28 days), water absorption, porosity, compressive, and flexural strength tests were conducted at 28- and 90-day water curing time on 40×40×160 mm prismatic hardened samples and flow table test on fresh mortar. There was a slight reduction of the unit weight, an increased workability, and decreased water absorption and porosity; a little reduction of the compressive strength and flexural strength were seen after the tests. In addition, the expansions of mortar were measured up to 90 days. When 14 days expansions were considered according to ASTM C1260, addition of waste G and F separately reduced the expansion that occurred due to ASR. However, the mixture containing 15% waste G and 15% F together (GF-30) exhibited the lowest expansion in the order of 0.02% which was far lower than 0.10%. The higher replacement ratio of waste G and F together and separately caused lower expansion in mortar.
Downloads
References
Abbas, Safeer, Syed M. S. Kazmi, and Muhammad J. Munir. 2017. “Potential of Rice Husk Ash for Mitigating the Alkali-Silica Reaction in Mortar Bars Incorporating Reactive Aggregates.” Construction and Building Materials 132:61–70. doi: 10.1016/j.conbuildmat.2016.11.126.
Adesina, Adeyemi, and Sreekanta Das. 2020. “Influence of Glass Powder on the Durability Properties of Engineered Cementitious Composites.” Construction and Building Materials 242:118199. doi: 10.1016/j.conbuildmat.2020.118199.
Afshinnia, Kaveh, and Prasada Rao Rangaraju. 2015. “Efficiency of Ternary Blends Containing Fine Glass Powder in Mitigating Alkali-Silica Reaction.” Construction and Building Materials. doi: 10.1016/j.conbuildmat.2015.09.043.
ASTM C1260. 2014. “Standard Test Method for Potential Alkali Reactivity of Aggregates ( Mortar-Bar Method).” West Conshohocken, PA, USA: ASTM.
ASTM C642-13. 2013. Standard Test Method for Density, Absorption, and Voids in Hardened Concrete. West Conshohocken: ASTM.
ASTM Standard C33. 2003. “Standard Specification for Concrete Aggregates.” ASTM International.
Bleszynski, R. F., and M. D. A. Thomas. 1998. “Microstructural Studies of Alkali-Silica Reaction in Fly Ash Concrete Immersed in Alkaline Solutions.” Advanced Cement Based Materials. doi: 10.1016/S1065-7355(97)00030-8.
Bueno, Eduard Tora, Jerry M. Paris, Kyle A. Clavier, Chad Spreadbury, Christopher C. Ferraro, and Timothy G. Townsend. 2020. “A Review of Ground Waste Glass as a Supplementary Cementitious Material: A Focus on Alkali-Silica Reaction.” Journal of Cleaner Production 257:120180. doi: 10.1016/j.jclepro.2020.120180.
Cai, Yamei, Dongxing Xuan, and Chi Sun Poon. 2019. “Effects of Nano-SiO2 and Glass Powder on Mitigating Alkali-Silica Reaction of Cement Glass Mortars.” Construction and Building Materials 201:295–302. doi: 10.1016/j.conbuildmat.2018.12.186.
Comi, Claudia, Beatrice Kirchmayr, and Rossella Pignatelli. 2012. “Two-Phase Damage Modeling of Concrete Affected by Alkali-Silica Reaction under Variable Temperature and Humidity Conditions.” International Journal of Solids and Structures. doi: 10.1016/j.ijsolstr.2012.07.015.
Drolet, C., J. Duchesne, and B. Fournier. 2017. “Effect of Alkali Release by Aggregates on Alkali-Silica Reaction.” Construction and Building Materials. doi: 10.1016/j.conbuildmat.2017.09.085.
Du, Hongjian, and Kiang Hwee Tan. 2013. “Use of Waste Glass as Sand in Mortar: Part II - Alkali-Silica Reaction and Mitigation Methods.” Cement and Concrete Composites 35(1):118–26. doi: 10.1016/j.cemconcomp.2012.08.029.
EN 1015-11. 2006. “Methods of Test for Mortar for Masonry.” Part 11: Determination of Flexural and Compressive Strength of Hardened Mortar.
EN 1015-3. 1999. “Methods of Test for Mortar for Masonry.” Part 3: Determination of Consistence of Fresh Mortar (by Flow Table).
Erdoğan, Turhan. 1997. Admixtures for Concrete. Ankara, Turkey: Middle East Technical University Press.
Fanijo, Ebenezer O., Emad Kassem, and Ahmed Ibrahim. 2021. “ASR Mitigation Using Binary and Ternary Blends with Waste Glass Powder.” Construction and Building Materials 280:122425. doi: 10.1016/j.conbuildmat.2021.122425.
Gautam, Bishnu P., and Daman K. Panesar. 2017. “The Effect of Elevated Conditioning Temperature on the ASR Expansion, Cracking and Properties of Reactive Spratt Aggregate Concrete.” Construction and Building Materials. doi: 10.1016/j.conbuildmat.2017.02.104.
He, Pingping, Binyu Zhang, Jian Xin Lu, and Chi Sun Poon. 2020. “A Ternary Optimization of Alkali-Activated Cement Mortars Incorporating Glass Powder, Slag and Calcium Aluminate Cement.” Construction and Building Materials 240. doi: 10.1016/j.conbuildmat.2019.117983.
International, Astm, and files indexed by mero. n.d. Standard Specification for Reagent Water 1.
Kamali, Mahsa, and Ali Ghahremaninezhad. 2015. “Effect of Glass Powders on the Mechanical and Durability Properties of Cementitious Materials.” Construction and Building Materials 98:407–16. doi: 10.1016/j.conbuildmat.2015.06.010.
Kandasamy, Seyon, and Medhat H. Shehata. 2014. “The Capacity of Ternary Blends Containing Slag and High-Calcium Fly Ash to Mitigate Alkali Silica Reaction.” Cement and Concrete Composites. doi: 10.1016/j.cemconcomp.2013.12.008.
Moser, Robert D., Amal R. Jayapalan, Victor Y. Garas, and Kimberly E. Kurtis. 2010. “Assessment of Binary and Ternary Blends of Metakaolin and Class C Fly Ash for Alkali-Silica Reaction Mitigation in Concrete.” Cement and Concrete Research 40(12):1664–72. doi: 10.1016/j.cemconres.2010.08.006.
P. Kumar Mehta, and Paulo J. M. Monteiro. 2014. Concrete: Microstructure, Properties, and Materials. 4th Ed. New York: McGraw-Hill Education.
Park, Seung Bum, and Bong Chun Lee. 2004. “Studies on Expansion Properties in Mortar Containing Waste Glass and Fibers.” Cement and Concrete Research 34(7):1145–52. doi: 10.1016/j.cemconres.2003.12.005.
Schwarz, Nathan, Hieu Cam, and Narayanan Neithalath. 2008. “Influence of a Fine Glass Powder on the Durability Characteristics of Concrete and Its Comparison to Fly Ash.” Cement and Concrete Composites 30(6):486–96. doi: 10.1016/j.cemconcomp.2008.02.001.
Shafaatian, Seyed M. H., Alireza Akhavan, Hamed Maraghechi, and Farshad Rajabipour. 2013. “How Does Fly Ash Mitigate Alkali-Silica Reaction (ASR) in Accelerated Mortar Bar Test (ASTM C1567)?” Cement and Concrete Composites. doi: 10.1016/j.cemconcomp.2012.11.004.
Shehata, Medhat H., and Michael D. A. Thomas. 2000. “Effect of Fly Ash Composition on the Expansion of Concrete Due to Alkali-Silica Reaction.” Cement and Concrete Research. doi: 10.1016/S0008-8846(00)00283-0.
Shehata, Medhat H., and Michael D. A. Thomas. 2006. “Alkali Release Characteristics of Blended Cements.” Cement and Concrete Research. doi: 10.1016/j.cemconres.2006.02.015.
Shi, Zhenguo, Caijun Shi, Jian Zhang, Shu Wan, Zuhua Zhang, and Zhihua Ou. 2018. “Alkali-Silica Reaction in Waterglass-Activated Slag Mortars Incorporating Fly Ash and Metakaolin.” Cement and Concrete Research 108:10–19. doi: 10.1016/j.cemconres.2018.03.002.
Swamy, R. N. 1991. The Alkali-Silica Reaction in Concrete. 1st editio. London: CRC Press.
Topçu, Ilker Bekir, Ahmet Raif Boǧa, and Turhan Bilir. 2008. “Alkali-Silica Reactions of Mortars Produced by Using Waste Glass as Fine Aggregate and Admixtures Such as Fly Ash and Li2CO3.” Waste Management 28(5):878–84. doi: 10.1016/j.wasman.2007.04.005.
Ye, Hailong, and Zhijian Chen. 2019. “Mechanisms of Alkali-Silica Reaction in Alkali-Activated High-Volume Fly Ash Mortars.” Journal of Advanced Concrete Technology 17(6):269–81. doi: 10.3151/jact.17.269.
Zheng, Keren. 2016. “Pozzolanic Reaction of Glass Powder and Its Role in Controlling Alkali-Silica Reaction.” Cement and Concrete Composites. doi: 10.1016/j.cemconcomp.2015.12.008.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2023 Yusuf Gökşen, Uğur Durak, Serhan İlkentapar, İsmail İsa Atabey, Mehmet Kaya, Okan Karahan, Cengiz Duran Atis
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.
